气动电磁阀的维护方法
发布时间：2014-11-25 19:33 已被浏览 95 次
气动电磁阀的日常维护要点如下：
1，对消除气动电磁阀内杂质清除定期，气动电磁阀，检查磨损严重的情况的所有部分，并根据实际情况，考虑更换或修理损坏的部件。
2，当要拆卸气动电磁阀，一套完整的其他形式在电源和关闭连接，并注意过程中拆下电磁阀的安装序列的每个部分。
3，气动电磁阀故障的问题主要包括线圈和密封等易损部件，线圈烧坏由于过载，密封本身作为易损件，是由于自然的磨损和撕裂，长时间的作用下。
4，气动电磁阀工作时的振动，如果经常发生，很容易造成损坏的电磁阀，气动元件，所以电磁阀的维修，也应保证定期的气动电磁阀部件的工作环境的稳定性
固定，如螺栓，等。
5，如果气动电磁阀的工作环境是开放的可能导致气动电磁阀和部分生锈使电磁阀不能正常工作。所以需要维护，以保持性能稳定运行。
6，条件允许的情况下，如果气动电磁阀的工作是很重要的，这就需要一个专门的维修人员，确保电磁阀故障率低的工作稳定性。这样才能使工作效率更高，维修费用低，使用寿命长。
Pneumatic solenoid valve daily maintenance main points are as follows:
1, on a regular basis to remove the clear internal impurities of pneumatic solenoid valve, pneumatic solenoid valve ａnd check all parts for wear serious condition, ａnd according to the actual situation to consider replacement or repair damaged parts.
2, when to remove the pneumatic solenoid valve, power ａnd close the connection before the other form a complete set, ａnd pay attention to in the process of remove the solenoid valve installation sequence of each parts.
3, pneumatic solenoid valve malfunction problems mainly include coil ａnd seals ａnd other vulnerable parts, coil is burn out due to overload, seal itself as wearing parts, are due to natural wear ａnd tear under long time work.
4, pneumatic solenoid valve at work, if vibration often happens, it＇s easy to cause electromagnetic valve pneumatic components of damage, so maintenance of electromagnetic valve, also should guarantee the stability of the working environment of pneumatic electromagnetic valve parts on a regular basis
Fixed, such as bolts, etc.
5, if pneumatic solenoid valve work environment is open is likely to lead to the pneumatic solenoid valve ａnd parts of rust make electromagnetic valve cannot work normally. So the need for maintenance, to keep stable operation performance.
6, under the condition of allowing, if the pneumatic solenoid valve work is important, which requires a special maintenance personnel, ensure the working stability of the solenoid valve ａnd low failure rate. In this way can we make it work more efficient, lower maintenance cost, long service life.
国内相关
电磁阀产品：http://www.ansifm.com/diancifa/
国外相关
进口电磁阀产品：http://www.ansifm.com/fring/solenoidvalve/
【声明】： 以上文章或资料除注明为上海前泽阀门有限公司自创或编辑整理外，均为各方收集或网友推荐所得。其中摘录的内容以共享、研究为目的，不存在任何商业考虑。
目前网站上有些文章未注明作者或出处，甚至标注错误，此类情况出现并非不尊重作者及出处网站，而是因为有些资料来源的不规范。如果有了解作者或出处的原作者或网友，请告知，本网站将立即更正注明，并向作者道歉。
